The effect of the presence of nanoclay and basalt fibers on the tensile and impact mechanical properties of PLA/NR polymer composites using the response surface method (RSM)

Authors

1 Department of Mechanical Engineering, Faculty of Aerospace Engineering, Shahid Sattari Aeronautical University, Tehran, Iran

2 Faculty of Aerospace Engineering, Shahid Sattari Aeronautical University, Tehran, Iran

10.22044/jsfm.2026.16447.3984

Abstract

In this study, the effects of nanoclay and basalt fibers on the tensile and impact properties of PLA/NR polymer composites were experimentally investigated using the Response Surface Methodology (RSM). The studied variables included the weight percentage of nanoclay (0%, 3%, and 6%), basalt fibers (0%, 10%, and 20%), and natural rubber (0%, 15%, and 30%). The samples were prepared using an internal mixer and a hot press machine according to relevant standards. Tensile tests were conducted to determine tensile strength and elastic modulus, and Charpy impact tests were performed to evaluate impact strength. The results indicated that increasing the weight percentage of nanoclay at low concentrations improved tensile strength and elastic modulus by 10% and 21%, respectively, while higher percentages led to a reduction in mechanical properties. The addition of basalt fibers enhanced tensile strength, elastic modulus, and impact strength by 14%, 37%, and 39%, respectively. Increasing the natural rubber content resulted in a 44% improvement in impact strength but an 11% and 23% decrease in tensile strength and elastic modulus, respectively. Scanning electron microscopy (SEM) images were also used to analyze the dispersion of nanoparticles and basalt fibers within the polymer matrix.

Keywords

Main Subjects


[1] Tsai S (2018) Introduction to composite materials. Routledge, New York
[2] Omanović-Mikličanin E, Badnjević A, Kazlagić A, Hajlovac M (2020) Nanocomposites: a brief review. J Health Technol 10(1): 51-59
[3] Alsuwait RB, Souiyah M, Momohjimoh I, Ganiyu SA, Bakare AO (2022) Recent development in the processing, properties, and applications of epoxy-based natural fiber polymer biocomposites. Polym J 15(1): 145
 [4] Rajkumar A, Selvan MTGA, Neto V, Raja RS, Binoj JS, Bright BM (2025) Optimization and statistical analysis on mechanical, thermal, wear and water-absorption characteristics of fragrant screwpine fiber-reinforced polymer biocomposites. Iran Polym J 34(3): 399–412.
[5] Olaniyan OT, Adeyomoye O, Adetunji CO, Oloruntoba A (2024) Biocomposites for aerospace engineering applications. In: Advances in biocomposites and their applications. Woodhead Publishing, pp 285–298
[6] Mazlan N, Shah AUM, Hua TC, Najmi I, Ramli N (2024) Biocomposites as aircraft materials. In: Sustainable materials and manufacturing techniques in aviation. Springer, pp 27–53
[7] Yadav K, Dutta K, Poudel R, Karak N (2024) Biocomposites for automotive applications. In: Advances in biocomposites and their applications. Woodhead Publishing, pp 257–284
[8] Joseph A, Mahesh V, Harursampath D, Loja MAR, Bhowmik S (2024) Crashworthiness of biocomposites in automotive applications. In: Biocomposites for industrial applications. Elsevier, pp 169–194
[9] Ruz-Cruz MA, Herrera-Franco PJ, Flores-Johnson EA, Moreno-Chulim MV, Galera-Manzano LM, Valadez-González A (2022) Thermal and mechanical properties of PLA-based multiscale cellulosic biocomposites. J Mater Res Technol 18:485–495
[10] Trivedi AK, Gupta MK, Singh H (2023) PLA based biocomposites for sustainable products: A review. Adv Ind Eng Polym Res 6(4):382–395
[11] Wu CS, Liao HT (2020) Study on the properties of polylactic acid/natural rubber blends: mechanical performance, thermal behavior, and biodegradability. Polym Test 81:106267
[12] Pongputthipat W, Ruksakulpiwat Y, Chumsamrong P (2023) Development of biodegradable biocomposite films from poly (lactic acid), natural rubber and rice straw. Polym Bull 80(9):10289-10307
[13] Koeipudsa N, Phinyocheep P (2024) Cellulose nanocrystals from oil palm trunk biomass as a bio-reinforcing filler for improved mechanical properties of modified natural rubber composites. Polym Compos 45(5):4524-4537
[14] Kirve M, Munde Y, Shinde A, Siva I (2022) Evaluation of mechanical properties of bamboo epoxy bio-composite filled with montmorillonite nanoclay. Mater Today Proc 62:806-810
[15] Kausar A, Ahmad I, Maaza M, Eisa MH (2022) State-of-the-art nanoclay reinforcement in green polymeric nanocomposite: from design to new opportunities. J. Minerals 12(12):1495
[16] Voicu RC, Gologanu M, Tibeica C, Santiago-Calvo M, Asensio M, Cañibano E, Sandu T (2024) Prediction of mechanical properties of nano-clay-based biopolymeric composites. J. Nanomater14(17):1403
[17] Taghipoor H, Mirzaei J (2024) Optimizing mechanical behavior in polymer bio-composites reinforced with basalt, graphene, and PP-g-MA. Phys Scr 99(9):095987
[18] KR P, Bheemappa S (2025) Experimental investigations on the mechanical behavior of basalt fabric reinforced epoxy composites. J Polym Res 32(3):1-20
[19] Montgomery DC (2017) Design and analysis of experiments. Wiley, Hoboken
[20] Eriksson L, Johansson E, Kettaneh-Wold N, Wikström C, Wold S (2000) Design of experiments: principles and applications. Learn Ways AB, Stockholm
[21] Ray, S. S., & Okamoto, M. (2003). Polymer/layered silicate nanocomposites: a review from preparation to processing. Prog. Polym. Sci., 28(11), 1539–1641.
[22] Zhang, W., et al. (2008). Toughening of epoxy resins by nanosilica particles: Mechanisms and modeling. Polym. Sci. Eng., 48(4), 765–774.
[23] Pegoretti, A., et al. (2009). Fracture toughness of polylactic acid (PLA) nanocomposites: Effect of nanofiller type and content. Polym. Test., 28(8), 805–811.
[24] Luo, J. J., & Daniel, I. M. (2003). Characterization and modeling of mechanical behavior of polymer nanocomposites. Compos. Sci. Technol., 63(11), 1607–1616.
[25] Liu, T., et al. (2005). Tailoring the interface creation of nanocomposites via in situ polymerization. Macromol. Mater. Eng., 290(5), 351–360.
[26] O’Connell, D. W., et al. (2012). Nanoparticle-induced strengthening in polymer nanocomposites. Compos. Sci. Technol., 72(14), 1665–1670.
[27] Wu, Q., et al. (2020). Mechanical reinforcement and thermal stability of PLA-based hybrid composites reinforced with natural fibers and nanoclay. Polym. Compos., 41(6), 2209–2220.
[28] Kornmann, X., et al. (2001). Clay-reinforced epoxy nanocomposites. Polym., 42(3), 1353–1362.
[29] Sapayan, T., et al. (2016). Effect of clay agglomeration on the mechanical and thermal properties of polylactide nanocomposites. J. Appl. Polym. Sci., 133(30), 43782.
[30] Alexandre, M., & Dubois, P. (2000). Polymer-layered silicate nanocomposites: preparation, properties and uses of a new class of materials. J. Mater. Sci. Eng., 28(1-2), 1–63.
[31] Sinha, V., et al. (2010). Progress in recycled PLA-based blends, composites and nanocomposites. Polym-Plast. Technol. Eng., 49(16), 1611–1625.
[32] Hussain F, Hojjati M, Okamoto M, Gorga RE (2006) Review: polymer-matrix nanocomposites. J Mater. Sci. 41:3289-3297
[33] Phetwarotai W, Potiyaraj P, Aht-Ong D (2021) Development of biodegradable biocomposite films from poly(lactic acid), natural rubber and rice straw. Int J Biol Macromol 183:1530-1538.
[34] Taib NAAB, Rahman MR, Huda D, Kuok KK, Hamdan S, Bin Bakri MK, Julaihi MRBM, Khan A (2023) PLA-based biocomposites for sustainable products: a review. Polym. 15(12):2817
[35] Chen L, Yang J, Zhu M, Huang T. Toughening of PLA with natural rubber: Morphology and impact behavior of binary and ternary blends. Polym. Test. 2023;117:107821.
[36] Zhang Y, Liu X, Wang L, Chen J, Li H (2023) Tailoring the dispersion of nanoclay in PLA-based nanocomposites: effects on mechanical and thermal properties. Compos Sci Technol 242:110215.
[37] Kumar A, Singh RK, Mishra S. Mechanical and thermal properties of polylactic acid nanocomposites reinforced with montmorillonite clay. Polym Compos. 2022;43(9):6245-56.
[38] Chen X, Wu Y, Zhang Q, Yang F, Sun P (2023) Critical nanoclay content for optimal mechanical performance in biodegradable polymer composites. Mater Today Commun 36:106568.
[39] Liu Y, Zhang H, Wang Q, Li C. Basalt fiber reinforced polylactic acid composites: Mechanical performance and interfacial characterization. Mater Des. 2021;205:109732.
[40] Zhao T, Li J, Wang H, Zhang K, Liu Y (2024) Ultra-high modulus basalt fiber reinforced PLA composites: interface optimization and mechanical enhancement. Compos Sci Technol 248:110487.
[41] Gao J, Li W, Wang J, Wang X, Sha C, Zhao K (2024) Comprehensive analysis of fused deposition modeling process conditions for enhancing mechanical properties and surface quality of 3D-printed poly-ether-ether-ketone. Polym. Test 134:108432
[42] Paul, D. R., & Robeson, L. M. (2008). Polymer nanotechnology: Nanocomposites. Polym., 49(15), 3187–3204.
[43] Sun D, Liang X, Ning H, Hu N (2024) Global sensitivity analysis for degraded braided composite with interval process. Compos Sci Technol 250:110542
[44] Wu Q, Zhang Y, Liu X, Wang H. Mechanical reinforcement and thermal stability of PLA-based hybrid composites reinforced with basalt fibers and nanoclay. Polym Compos.
 [45] Garcia JM, Rodriguez-Lopez A, Martinez-Sanz M, Lopez-Rubio A, Lagaron JM (2024) Sustainable toughening of PLA using natural rubber: processing-structure-property relationships. ACS Sustain Chem Eng 12(5):2345-2356.